A little crazy?

Corrosion, Paint, Through Hulls, etc.
Post Reply
TinLizzy
Royal Aluminum Star
Posts: 264
Joined: Mon Jan 19, 2015 11:07 pm
Location: Lake Superior-Michigan's U.P.

Re: A little crazy?

Post by TinLizzy »

There was a few factory triangles cut in a few of the original webbing stringers, and we also added a few. Water does drain to the keel, although slow at times.
Rodney
1975 28 Express-Twin 350 Chevy's, SOLD
1990 32 Express--Twin Mercruiser 454 with Bravo I outdrives
Portage Canal Waterway-Upper Peninsula,Lake Superior
Fastjeff
Site Admin
Posts: 1521
Joined: Sat Jul 12, 2014 5:06 am
Location: Rock Halll, MD

Re: A little crazy?

Post by Fastjeff »

Fascinating project!

Sure wish I lived nearby so I could give you a helping hand.

Jeff
"We live at the bottom of an ocean of air, not at the top." General Marvage Slatington
TinLizzy
Royal Aluminum Star
Posts: 264
Joined: Mon Jan 19, 2015 11:07 pm
Location: Lake Superior-Michigan's U.P.

Re: A little crazy?

Post by TinLizzy »

Thanks Jeff!
Rodney
1975 28 Express-Twin 350 Chevy's, SOLD
1990 32 Express--Twin Mercruiser 454 with Bravo I outdrives
Portage Canal Waterway-Upper Peninsula,Lake Superior
TinLizzy
Royal Aluminum Star
Posts: 264
Joined: Mon Jan 19, 2015 11:07 pm
Location: Lake Superior-Michigan's U.P.

Re: A little crazy?

Post by TinLizzy »

boat lift.jpg
boat hanging.jpg
Swapped trailers under boat. Borrowed a buddies trailer for it to sit on after the engines go in. Old trailer was too short and did not support the stern at all. We used a fork lift, loader and a couple tow straps to and it for the swap.
Rodney
1975 28 Express-Twin 350 Chevy's, SOLD
1990 32 Express--Twin Mercruiser 454 with Bravo I outdrives
Portage Canal Waterway-Upper Peninsula,Lake Superior
TinLizzy
Royal Aluminum Star
Posts: 264
Joined: Mon Jan 19, 2015 11:07 pm
Location: Lake Superior-Michigan's U.P.

Re: A little crazy?

Post by TinLizzy »

better trailer.jpg
Sitting on better trailer until I can lengthen the old one.
Rodney
1975 28 Express-Twin 350 Chevy's, SOLD
1990 32 Express--Twin Mercruiser 454 with Bravo I outdrives
Portage Canal Waterway-Upper Peninsula,Lake Superior
TinLizzy
Royal Aluminum Star
Posts: 264
Joined: Mon Jan 19, 2015 11:07 pm
Location: Lake Superior-Michigan's U.P.

Re: A little crazy?

Post by TinLizzy »

ext transom assembly.jpg
Transom assemblies installed for the last time I hope!
Rodney
1975 28 Express-Twin 350 Chevy's, SOLD
1990 32 Express--Twin Mercruiser 454 with Bravo I outdrives
Portage Canal Waterway-Upper Peninsula,Lake Superior
TinLizzy
Royal Aluminum Star
Posts: 264
Joined: Mon Jan 19, 2015 11:07 pm
Location: Lake Superior-Michigan's U.P.

Re: A little crazy?

Post by TinLizzy »

stern drive install.jpg
Engines mounted, transom assemblies installed, engines aligned, outdrives installed. Slapped some primer on the bare metal.
Rodney
1975 28 Express-Twin 350 Chevy's, SOLD
1990 32 Express--Twin Mercruiser 454 with Bravo I outdrives
Portage Canal Waterway-Upper Peninsula,Lake Superior
Fastjeff
Site Admin
Posts: 1521
Joined: Sat Jul 12, 2014 5:06 am
Location: Rock Halll, MD

Re: A little crazy?

Post by Fastjeff »

Have you tried the Fastjeff jump on the cavitation plate to see if it moves test?

Jeff
"We live at the bottom of an ocean of air, not at the top." General Marvage Slatington
TinLizzy
Royal Aluminum Star
Posts: 264
Joined: Mon Jan 19, 2015 11:07 pm
Location: Lake Superior-Michigan's U.P.

Re: A little crazy?

Post by TinLizzy »

Jeff, the transom has passed the jump method, and the full throttle method. Both passed with flying colors. The welder and a couple engineers that looked it over were quite confident in the end product.
Rodney
1975 28 Express-Twin 350 Chevy's, SOLD
1990 32 Express--Twin Mercruiser 454 with Bravo I outdrives
Portage Canal Waterway-Upper Peninsula,Lake Superior
TinLizzy
Royal Aluminum Star
Posts: 264
Joined: Mon Jan 19, 2015 11:07 pm
Location: Lake Superior-Michigan's U.P.

Re: A little crazy?

Post by TinLizzy »

bad paint job.jpg
Paint job is quite bad, I had run out of time to get a decent color match. So I just slapped some paint on it before the launching to cover up the primer. Next spring I plan on repainting the whole boat from the rub rail down to the bottom paint.
Rodney
1975 28 Express-Twin 350 Chevy's, SOLD
1990 32 Express--Twin Mercruiser 454 with Bravo I outdrives
Portage Canal Waterway-Upper Peninsula,Lake Superior
Post Reply